Reliant FVIR GAS WATER HEATER Guide d'utilisation et d'entretien

1This water heater complies with ANSI Z21.10.1-current edition regarding the accidental or unintended ignition of fl ammable vapors, such as those emit

10LP Gas Only WARNINGExplosion HazardHave a qualified person make sure L.P. gas pre

11TABLE 3BTUH InputMinimum SquareFeet with8’ CeilingTypical Roomwith 8’ Ceiling30,000 188 9 x 2145,000 281 14 x 2060,000 375 15 x 2575,000 469 15 x 31

1212” MAXIMUMPERMANENTOPENINGS TOTHE OUTSIDE OR ADDITIONAL ROOMS WITHINTHE BUILDINGCLOSETOR OTHER CONFINED SPACE12” MAXIMUMFIGURE 6.All Air from Insid

13ALTERNATIVEOPENINGLOCATION1 SQ. INCH PER 3000 BTUHCONFINEDSPACEALL AIR FROM OUTDOORS - USING A SINGLE PERMANENT OPENINGFIGURE 11.Vent Pipe System

14Align the legs of the draft hood with the slots provided. Insert the draft hood leg tips into slots on the flue damper’s flange as shown in Figure 1

15Piping Installation Piping, fittings, and valves should be installed according to the installation

16SUITABLE DRAINHOT WATEROUTLETCOLD WATERINLETPRESSURE REDUCING VALVE WITH BYPASSCOLD WATER SUPPLY TO FIXTURESCOLD WATER INLET VALVE(SHUT-OFF VALVE)IN

17The Discharge Line: • Must not be smaller than the pipe size of the relief valve or have any reducing coupling installed in the discharge line.• M

18□ Fresh air openings sized correctly with consideration given to the blocking effect of louvers and grilles.□ Ductwork is the same cross-sectional

19WARNINGExplosion HazardReplace view port if glass is missingor damaged.Failure to do so can result in death,explosion or fire.Lighting Instructions

2TABLE OF CONTENTSWater Heater Safety ...

20Water Temperature Regulation Water temperature over 125°F (52°C) can cause servere burns instantly resulting in se

21Gas Control/Temperature KnobStatus LightONOFFSTATUS120°FPositionA B C • •VERYHOTHOTLOWVA CA B C •

22ELECTRICAL CONNECTIONS/WIRING DIAGRAMElectrical Connections Before plugging in the water heater, always ma

23periods of heat-up and cool-down.2. Condensation causes sizzling and popping within the burner area and should be considered normal.3. Sediment bu

24Anode Rod/Water OdorEach water heater contains at least one anode rod, which will slowly deplete while protecting the glass-lined tank from corrosio

25properly. To prevent water damage, the valve must be properly connected to a discharge line which terminates at an adequate drain. Standing clear of

26Removing the Burner from the Manifold/Burner Assembly Natural Gas (Low Nox) & L.P. Gas Burn

27Cleaning the Combustion Chamber and Flame-arrestor 1. Follow procedure outlined in “Removing t

28MANIFOLD TUBEBRACKETTABSLOTBURNERCLOSE-UP INSIDE VIEW OFTHE COMBUSTION CHAMBER.FIGURE 34.Igniter System The

29FVIR System Operational Checklist 1. Manifold gasket properly sealed.2. Viewport not damaged or cracked.3. Fla

3SAFE INSTALLATION, USE AND SERVICEYour safety and the safety of others is extremely important in the installation, use and servicing of this water he

30INSUFFICIENT HOT WATER 1. Thermostat set too low2. Sediment or lime in tank3. Water heater too small4. Wrong piping connections5. Leaking faucet

31STATUS LIGHT TROUBLESHOOTING FLOWCHARTStatus Light CodeLED FLASH SEQUENCECONTROL STATUS CORRECTIVE ACTIONShort flash once every four second IDLE (No

32STATUS LIGHT TROUBLESHOOTING FLOWCHARTLED FLASH SEQUENCECONTROL STATUS CORRECTIVE ACTIONSix-Two Flash, three second pause Soft Lockout* - Recycle Li

33SEQUENCE OF OPERATION CHARTApply Powerto Appliance.Is Damper Closed?YIs there a Call for Heat.Is Damper Open?Will not attempt to light. 2 flash erro

34REPAIR PARTS ILLUSTRATIONLEGENDSpecial anode rod (see Anode Rod/Water Odor section)Temperature and Pressure Relief Valve is required, but may not be

35Listed Parts Kits and IllustrationsItem 12A: Pilot/Igniter-Flame Sensor assembly kit, which contains the pilot, igniter-flame sensor, and retainer

36NOTES

37NOTES

38NOTES

39THIS WARRANTY IS APPLICABLE TO THE ORIGINAL OWNER ONLY in accordance with the warranty terms and conditions specifi ed below.Reliance Water Heater Co

4Fire or Explosion HarzardDo not store or use gasoline or other flammable vapors andliquids in the vicinity of this or any other appliance. Avoid all

40Copyright © 2010 Reliance Water Heater Company. All rights reserved. administrative charges, and for any materials and/or permits required for in

5TYPICAL INSTALLATIONGET TO KNOW YOUR WATER HEATER - GAS MODELS A Vent Pipe B Draft Hood C Anode (Not Shown) D Hot Water Outlet E Insulation F

6INSTALLING YOUR GAS WATER HEATERImportant Information About This Water Heater This gas water heater was manufactured to voluntary safety standa

7FV SensorFIGURE 1.The patented system protects your family by trapping the burning vapors within the water heater combustion chamber through the spec

8IMPORTANT: The water heater should be located in an area where leakage of the tank or connections will not result in damage to the area adjacent to t

9CHECK WITHLOCAL UTILITYFOR MINIMUM HEIGHT3” MINIMUMDRIP LEGGROUND JOINTUNIONMANUAL GAS SHUT-OFF VALVESUITABLE DRAIN6” MAXIMUMAIR GAPDISCHARGE PIPE(DO